All the required packages in the sub-seam seam. According to the caps, sleeves and back off the order sheet, clothing and body to fold back. Generally velvet is opposite to the fabric. Down clothes sewing technique has its particularity.

Line reference samples and drawings.The surface where gall material be required by the version of the CD standard is not missing pieces multi-chip.Plus cotton parts: 100g loose cotton: hat in × 1,
cap piece × 2; 200g cotton: collar; 100g needles: 1 / 2 small collar, placket, 1 / 2 pocket mouth × 2Plus gall material parts: placket, pocket mouth, small collar, and collar.Production steps|Plus cholesterol mine feeding site: fly, pocket mouth, small collar, collar,Reference lines like clothing and drawings|Line reference samples and drawings}.From 11 - 13-pin pin / 3cm open air track, 12-14-pin / 3cm dark trace. Commissural with a 11 # needle, wire needle with a 9 #.Along the color line, and body surface line.All parts to be straight line, sewing thread trace 30cm may not have two single hop and continuous stitch, stitch does not allow skipping. Surface, bottom line should be tight, landing to fight back needle.Sleeve Chouse: unlined chip Chouse first, and then charge down the sodium line. Pleating lines and the shoulder seam to seam.Steam eyes with color across the mattress.A large zipper requirements for smooth, not fire. Placket chain pull head asked Zola to right insert, editor of 0.1cm line.Main label, trumpet nails in it after; washing superscript in it the left side seam of 1 / 2 standard.All lining joint request packet seam, Pointing cloth inside cuffs.Pocket 1CM decorative line after the line first filling cashmere series.By cotton cloth, hats week 0.1cm open wire loop to go, hat before the mouth 0.1 +2.5 cm open wire at the end of the mouth with 0.1 open wires. Hat bottom port 0.1 open. Specific reference is satisfied line drawings.The shoulder seam, armpit, belt pocket of Bucharest.Semi-finished products have small hot, flat ironing clothes; no aurora.Other specific practice reference sampleAll garments must be steam ironing, semi-finished cars cage small hot.No strings, no grease, no powder. Pocket without debris. Tidy, clean, smooth.Suture requires ironing hot uniform, no aurora|Suture ironing uniform requirements, no Aurora}.Package:According to the caps, sleeves and back off the order sheet, clothing and body to fold back.Packaging, logo, etc. in order to play according to Quit, Li-ping, buckle at the zipper top.According to the ratio of packing, required clothing folded neatly and evenly.The box must be marked section number, name, shape, color, quantity, unit of production.The body must indicate the number, name, size, color, quantity, production unit.Down materials are mainly down and coated fabrics. `down: penniless and velvet child (also known as velvet flower) mixture Ducks and geese have more hair, by the washing of isolated penniless and velvet jackets of the child as wadding. Down with gray two, white is preferred. Down the quality, charge down the volume and cashmere. Cashmere filling quantity of a down jacket quilted into feather weight, with gram, typically 250 grams, cashmere filling amount, thermal difference; with cashmere content in finger down son, expressed as a percentage, generally with a fleece weight of 50 to 80%. With cashmere high, is of good quality. Down the heat because the body can not easily lost child, and soft, but not after compression and wet time muster, and penniless muster at this time is to make clothes fluffy and there are more clothes to keep the air, there help keep warm, but the penniless more calories easily dispersed, and hairy stems sense. So down the child must be eclectic and penniless, the proportion of properly. The coated fabric with weft yarn high density of silk, cotton, cotton / polyester fabrics, the rolling processing, so that the weft yarn interstices between contractible, and then coated with a polymer slurry, and make the fabric forming a transparent coating layer covering the delivery chain, to seal the fabric gap} Some in the coating slurry adding fluoride phosphate resin or silicone waterproofing agent, so that the fabric has dew proof cashmere, water impervious performance. The 1980s have been without a special high density fabric coating, can also play the anti-dew down, the role of seepage water and ventilation. Downing the fabric points for hard and soft second-class. Polyester, Dacron, cotton belonging to government hard, wear leveling; silk taffeta, Nisi Fang is a soft, comfortable to wear.Down under the general source can be divided into goose and duck down, according to the color is divided into white cashmere and grey flannel, in addition of course, there are Iceland eider produce black cashmere and so on. Relatively speaking, better down the general from larger, more mature birds, the goose will be slightly better than duck down. From the color of speaking, white cashmere because it is white, can be used for light fabric instead of translucent color, a grey flannel is more popular.Ingredients :range from 5% to 95% from. For example you can say: 90% white goose down, etc.Charge down the amount: it is not a measure of the amount of down filling down the quality indicators, it is a down jacket filled with all the weight down. General the charge down the amount of outdoor jacket design is different depending on the target at 250-450 grams.Specie (down content): with cashmere down inside the proportion, generally expressed as a percentage. Outdoor cashmere jacket is generally above 80%, the data content of the surface of which is down 80% feather is accounting for 20%.Fluffy (fill power): Fluffy is the measure of warm down the main index of degree, refers to certain conditions every ounce (30 grams) down the volume cubic inches of numerical. If an ounce of down space required is 600 cubic inch said down the fluffy degree 600. The higher the degree of fluffy down, indicating that under the same charge down the amount of down can be fixed to a larger volume of air layer insulation and heat insulation, so the better the warmth of down. Fluffy at home is not a rigid index, and the measurement of relative error is larger.Down jacket fabric basic requirementsWind ventilation: Most of the outdoor jacket has a certain degree of wind resistance.  Ventilation is the outdoor clothing uniform requirements, but many tour pal but often ignore the importance of down jacket fabric air permeability. A gas-tight down in the mountains the results are often fatal.Proof: enhanced feather fabrics down prevention in three ways, one is covered or coated on the base cloth, through the film or coating to prevent leakage of cashmere, of course, principal premise is breathable, and will not affect the fabric thin and soft degree. Two is the high density fabric through post-processing to improve the fabric itself, the down-proof properties. Third, in the inner layer of fabric down to add a layer of anti-flannel, flannel anti-good or bad will directly affect the quality of Shangri.Thin soft: In today's equipment lightweight down jacket lightweight fabric will directly affect the level of the overall weight of a down jacket, and soft fabrics, bulky down jacket for itself in terms of, will increase down clothes to wear comfort. On the other hand, thin soft fabric helps to better play the fluffy down, so warm and will be higherWaterproof: mainly for professional Yukon Fu, in cold environments and wear, down jacket fabric to directly replace the jacket usedDown fabric type:Waterproof coating (coating) fabrics.Somewhat that similar to the type of fabrics jacket with waterproof breathable performance, generally be used for professional mountain down jacket. But the difference is, fabric overall than assault garment fabric is more frivolous soft. In addition because down in cold environments, mainly aimed at the ice and snow melt water to water in the solid state, so the fabric resistant to water pressure requirements will not be like the jacket so high, and most of the down jacket is made of waterproof fabric without a pressure adhesive Another point to note is that some of the low-down jacket in order to prevent leakage down the use of airtight coated fabric, if only for daily wear, can barely be considered. On behalf of fabrics: dry loft, PROO-TEC LM and so on.High density water repellent fabricThe density of the fabric itself is high, generally above the 290T. Then fabric surface by high temperature fusion to reduce the gap in post-processing technology fabric to improve the anti-down nature. The thin fabric, soft degree is all down jacket fabric inside the highest, at the same time with windproof, waterproof, breathable performance. Type of fabric down jacket and sleeping bag is the most widely used method of fabrics, but the level of post-treatment process for the anti-velvet fabric of great influence. On behalf of fabrics: pretax, soft-b, and so onCommon velvet woven fabric with antiGenerally use lower density nylon or polyester, Down in the production when added in the anti-flannel fabric in the side, can play a role in down-proof, anti-down performance is good. The disadvantage is that anti-flannel jacket affected the flexibility, and increased Shangri from the weight. The most important thing is if you are using flannel, then anti-poor, Down the permeability will be greatly reduced, and after washing, anti-caking or flannel easily damaged. Another way is for anti-down process, the process is in the fabric of the inner layer rubber brush on a layer of anti-velvet, fabric feel poor, and airtight. The behalf of fabric is many but not well-known fabric manufacturers.Performance comparison of three types of fabric:said that the best performance; waterproof coating (coated) fabric breathable fabric is assumed to meet the requirements of the general anti-woven flannel fabric which is also assumed to be compliant. This table only basic reference value, the actual situation in the fabric according to three types of technology will have greater access.Down the basic requirements for accessories have two things: First, low temperature, because the use of the environment generally at low temperatures, cold intolerance of the materials is likely to break. Two is a durable, imagine, at thirty DEG C below zero your zipper pull suddenly damage are not, it will be what the outcome of.Zip:Down on the main chest zipper used in the main chain, zipper pocket closure; require the use of smooth, with auxiliary zipper anti-pinch device. Representative products: yak zipper series.Down on main rope buckle, buckle hat adjusting ladder button and zipper head supporting, require the use of smooth, closed firmly, and resistance to low temperature. Representation of the product: Multi-Knout series are fastener.Sewing thread is required after silicone oil soaked, can prevent the needle is pulled big leakage of cashmere, and the required strength as much as possible under the premise of fine.Velcro:Velcro-type using four weeks rounded, and preferably not hooks hair varieties.Down the sewing process has its own specialty. Down lighter weight, easy to wind drift away, making the majority of garment sewing when good shall only stay in charge down the charge inside the mouth down. In order to prevent falling down, piled, down into the flock should be fixed afterTo prevent the wire from the eye of a needle in drilled down, the system when required to do 11 small-type needles. Uncoated fabrics in general should be lined with synthetic paper.If you need more information visit our site: heated jacket women